Ou what a feeling!!! - AUSJEEPOFFROAD.COM Jeep News Australia and New Zealand


Go Back   AUSJEEPOFFROAD.COM Jeep News Australia and New Zealand > ASSOCIATED INTERESTS > The Public Carpark


Portal Register Forums Trading Your Jeep New Garage Mark All Read

Post New Thread  Reply
 
Thread Tools Search this Thread
  #1  
Old 12-07-2018
layback40's Avatar
layback40  layback40 is offline
Grumpy Old XJ Dsl Owner
 
Join Date: Jan 2011
Location: Northern Victoria
Posts: 13,305
What Jeep do I drive?: XJ
Likes: 3,634
Liked 6,079 Times in 4,013 Posts
Default Ou what a feeling!!!

News
Toyota 1GD-FTV bites the dust

Recently we did a six-vehicle comparison test in the outback of South Australia in Unsealed 4X4, pitting a bunch of current dual-cab utes against one another. During the testing, the HiLux Rugged X test vehicle’s 1GD-FTV dropped into ‘limp mode’ four times due to dust ingress.
It’s so dusty out here, even the dust has dust!

The new-tech 2.8L 1GD-FTV is the engine utilised across the current HiLux, Fortuner and Prado models after Toyota phased out the 3.0L 1KD-FTV, which itself is beginning to turn up many issues relating to injectors causing engine failure.

Specifically for the new-tech 1GD-FTV, Toyota Australia has admitted there is a design flaw in the air-inlet system that allows dust past the air filter, which in turn corrupt the sensor readings within the mass air flow sensor. The ECU then utilises these readings to determine the correct fuel ratios for the engine to run. The corrupted data then prompts the engine to go into limp mode, which is a potentially dangerous outcome in certain situations, say mid-way through overtaking. During our testing, we managed to reset the ECU & limp mode by disconnecting and reconnecting the battery (have you tried turning it off and back on again?)

While Toyota Australia’s spokesperson assured us that any dust making its way past the filter, would be very fine (less than 5-microns in size), they further stated that dust of this size is “not known to cause engine damage.” We’re not entirely sure on that one, but we’ve got a filtration expert on speed dial, so we’ll get back to you on that one.

Toyota Australia further went on to say, “as the vehicle is subject to reduced engine power (‘limp mode’) and can continue to be operated safely, it is not a safety related item that would require a recall,” so don’t expect a letter from Toyota asking you to come in and have the flaw rectified. They have only publicly acknowledged the flaw in the wake of our testing, however there was a dealer bulletin released in March last year, advising of the issue, and the owners should be advised to ‘clean their air filter more often in dusty conditions’, as well as to blow the MAF sensor out with compressed air when completing services.

With all this in mind, a request for a fix has apparently been sent back to Toyota Japan, so hopefully there will be design changes that should eliminate this issue.

After the issues with the 1KD injectors, and now further issues with dust ingress in the 1GD-FTV, it seems that Toyota’s reputation for making indestructible, unbreakable HiLuxes might be starting to waver. Stay tuned, as we’ll get back to you with our dusty expert’s thoughts on the 1GD eating dust as soon as we can get him on the phone!
__________________
98&01XJ VMs,06 KJCRD,I no longer question authority,I annoy it.More effect,less effort.10000Club

Sponsored Posts
  #2  
Old 13-07-2018
TR Laredo  TR Laredo is offline
Senior Newbie
 
Join Date: Aug 2015
Location: Mornington
Posts: 79
What Jeep do I drive?: WK2
Likes: 2
Liked 33 Times in 22 Posts
Check out my Ride(s)
Default

There's more info here:

https://www.news.com.au/technology/i...48954b3b51e234

Cheers
  #3  
Old 13-07-2018
Classic Boy's Avatar
Classic Boy  Classic Boy is offline
CrawlerStar
 
Join Date: Jun 2017
Location: Central Vic
Posts: 425
What Jeep do I drive?: WG
Likes: 16
Liked 133 Times in 109 Posts
Default

My son is in the mining industry and he told me that a few years back every mine spec vehicle purchased was a hilux without question, nowadays isuzu's are becoming popular and any current hilux whether privately owned or company vehicle that blows smoke from DPF issues (pretty common) is banned from entering the sites.
Likes: (1)
  #4  
Old 13-07-2018
lujabe  lujabe is offline
Newbie
 
Join Date: Jan 2015
Posts: 282
Likes: 32
Liked 124 Times in 71 Posts
Default

Interesting - I used to work for a shipping company exporting for a mine from a port in the gulf of carpentaria. They ran Ford Rangers because they believed them to be better performing vehicles and every bit as reliable as Toyotas. The general feeling was the Toyota’s were overrated and poor value.
__________________

2015 KL Cherokee Trailhawk
Likes: (1)
Sponsored Posts
  #5  
Old 13-07-2018
Nanook's Avatar
Nanook  Nanook is offline
AJOR Bronze
 
Join Date: Mar 2014
Location: Lake Macquarie, NSW.
Age: 49
Posts: 2,105
What Jeep do I drive?: JK
Likes: 555
Liked 817 Times in 573 Posts
Default

My work has pretty much got rid of all our Hiluxes due to issues with them. I unfortunately have one of the last ones.

Our vehicles have a tough life due to the kind of sites we use them on which is mainly to do with the mining industry.

I have personally owed 2 Hiluxes and they both were the biggest POS I've ever owned. I vowed long ago never to buy another.
__________________
Cheers,
Jamie
Likes: (1)
Post New Thread  Reply


Thread Tools Search this Thread
Search this Thread:

Advanced Search

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off


» Advertisements_AS2




Powered by vBadvanced CMPS v3.2.3



All times are GMT +10. The time now is 01:43 PM.




AJOR does not vouch for or warrant the accuracy, completeness or usefulness of any message, and are not responsible for the contents of any message. The messages express the views of the author of the message, not necessarily the views of AJOR or any entity associated with AJOR, nor should any advice be substituted as technical advice replacing that of a mechanic. You agree, through your use of this service, that you will not use AJOR to post any material which is knowingly false and/or defamatory, inaccurate, abusive, vulgar, hateful, harassing, obscene, profane, sexually oriented, threatening, invasive of a person's privacy, religious, political or otherwise violative of any law. You agree not to post any copyrighted material unless the copyright is owned by you or by AJOR. The owner, administrators and moderators of AJOR reserve the right to delete any message or members for any or no reason whatsoever. You remain solely responsible for the content of your messages, and you agree to indemnify and hold harmless AJOR, the administrators, moderators, and their agents with respect to any claim based upon transmission of your message(s). The use of profile signatures to intentionally mislead or misdirect any member on this forum is not acceptable and may result in your account being suspended. Any trip that is organised through the AJOR forum is participated at your own risk. If you or your vehicle is damaged it is your responsibility, not that of the person that posted the thread, message or topic initiating the trip, nor the organisers of AJOR or moderators of any specific forum. This forum and associated website is the property of AJOR.


Powered by vBulletin® Version 3.8.7
Copyright ©2000 - 2018, vBulletin Solutions, Inc.

AJOR © 2002 - 2018 AUSJEEPOFFROAD.COM. All corporate trademarked names and logos are property of their respective owners. Ausjeepoffroad is in no way associated with DaimlerChrysler Corporation or Fiat Jeep.
www.midlifemate.com wayalife.com jkwrangler.com ausjeepforum.com jk-forum.com canadianjeepoffroad.com cryptoprofitcalculator.net
vB Ad Management by =RedTyger=