|
|
16-11-2017
|
|
AJOR Bronze
|
|
Join Date: Apr 2013
Location: Blackall Outback Queensland
Posts: 1,736 What Jeep do I drive?: XJ
Likes: 1,286
Liked 947 Times in 637 Posts
|
|
well awg you might be right and at $25 the Chemiweld is worth a try just got some off ebay if this helps great I can put off the head job for a while
_____ooooo
/__l_l_,\____\,___
l_---l_l__l---[ ]llllll[ ]
_.(o)_)__(o)_)--o-)_)
__________________
96 XJ Limited LPG Conversion......
99 XJ Sport ... Finally on the Road
RC Mini Me
|
16-11-2017
|
I just registered
|
|
Join Date: Nov 2017
Location: Woodcroft 2767
Posts: 17 What Jeep do I drive?: JK
Likes: 0
Liked 0 Times in 0 Posts
|
|
Depending on what concentration your coolant is, you can actually smell it out of the exhaust, glycol has a "sweet" smell.
As for Chemiweld, I have used it in the past with varying degrees of success, it seems to hold much longer with water in the system, not glycol.
|
18-11-2017
|
|
CrawlerStar
|
|
Join Date: May 2017
Location: Victoria
Posts: 454 What Jeep do I drive?: XJ
Likes: 259
Liked 86 Times in 64 Posts
|
|
Quote:
Originally Posted by awg
I been following this thread cause my coolant dissapears from the res tank at the rate of ~1litre per 2000km.
It does not seem to be leaking out anywhere.
am going to make a home made cooling system pressure kit,
have a UV torch that shows up green coolant, so when i get time to take the abused DD off the road, will have to check it out
in the past, with head gaskets, there has always been a characteristic poor idle...with associated radiator bubbling and milky oil soon after...never had one "stay the same"..or get better
If I was as suspicious as you, I would be tempted to chuck in a bottle of Chemiweld, which can hold a minor crack or leak for ages
there would be little to lose
|
mine is similar, but uses a bit less. I think its leaking from the welsch plugs...
|
22-11-2017
|
|
AJOR Bronze
|
|
Join Date: Apr 2013
Location: Blackall Outback Queensland
Posts: 1,736 What Jeep do I drive?: XJ
Likes: 1,286
Liked 947 Times in 637 Posts
|
|
Well I will try the chemiweild but still think I need a HeadJob..... went down the river today to run the dog and there was drovers there with a mob of cattle so we went further out to the 18 mile as soon as I went up to 100kph the temp shot up to the red....
I have a newish rad water pump thermostat and cover hoses all the goodies on the trip home I stayed on 85kph under 2000 rpm temp held at 105 I had my fan override on as well I noticed just before dark a puddle or wet dirt under the expansion tank will have a good look tomorrow
better start saving my pennies
this might hurt in the mean time I will shove the chemiweild down its neck .....
_____ooooo
/__l_l_,\____\,___
l_---l_l__l---[ ]llllll[ ]
_.(o)_)__(o)_)--o-)_)
__________________
96 XJ Limited LPG Conversion......
99 XJ Sport ... Finally on the Road
RC Mini Me
|
22-11-2017
|
|
Grumpy Old XJ Dsl Owner
|
|
Join Date: Jan 2011
Location: Northern Victoria
Posts: 13,813 What Jeep do I drive?: XJ
Likes: 4,597
Liked 6,566 Times in 4,349 Posts
|
|
Quote:
Originally Posted by LuluBelle
Well I will try the chemiweild but still think I need a HeadJob..... went down the river today to run the dog and there was drovers there with a mob of cattle so we went further out to the 18 mile as soon as I went up to 100kph the temp shot up to the red....
I have a newish rad water pump thermostat and cover hoses all the goodies on the trip home I stayed on 85kph under 2000 rpm temp held at 105 I had my fan override on as well I noticed just before dark a puddle or wet dirt under the expansion tank will have a good look tomorrow
better start saving my pennies
this might hurt in the mean time I will shove the chemiweild down its neck .....
_____ooooo
/__l_l_,\____\,___
l_---l_l__l---[ ]llllll[ ]
_.(o)_)__(o)_)--o-)_)
|
Make sure you clean out the cooling system properly before you do the treatment. Follow the instructions properly. You dont just chuck it in. Has to be added the correct way for the correct time along with the correct driving during treatment & then flushed out. You can leave it a little longer to make sure its properly sealed.
Good Luck !
__________________
98&01XJVMs,06&07KJCRD's,No longer question authority,I annoy it.More effect,less effort.10000Club
|
28-11-2017
|
|
AJOR Bronze
|
|
Join Date: Apr 2013
Location: Blackall Outback Queensland
Posts: 1,736 What Jeep do I drive?: XJ
Likes: 1,286
Liked 947 Times in 637 Posts
|
|
thanks layback40.......well I got the chemiweld today read the destructions ....... engine flush coming up then I will chuck it down its neck and see what happens it wont take much for the xj to get hot running on water only lol if it buys me a few months great as I only do 11.5 k a day down the river and it is not over heating just surging and sluggish when cold but temps spike if you push it a bit I will eventually pull the head as I want to keep the xj
so I will let everyone know how things go in the next few days ..........................now more beer
_____ooooo
/__l_l_,\____\,___
l_---l_l__l---[ ]llllll[ ]
_.(o)_)__(o)_)--o-)_)
__________________
96 XJ Limited LPG Conversion......
99 XJ Sport ... Finally on the Road
RC Mini Me
|
02-12-2017
|
|
AJOR Bronze
|
|
Join Date: Apr 2013
Location: Blackall Outback Queensland
Posts: 1,736 What Jeep do I drive?: XJ
Likes: 1,286
Liked 947 Times in 637 Posts
|
|
well I think I am going to chicken out on the chemiweld I have read so many reviews my head is spinning....or is it the homebrew
needless to say about 70% say its shit hot if the directions are followed...and about 30% say its trouble if you intend to keep the engine/car..................
my cooling system is newish all under 3 yrs old and I don't want to chance gumming it up .... I think I might get a compression tester off ebay only around $20 and test my compression see if the gasket has let go between cylinders
I will post my results of the compression test in the mean time I only drive it 11.5 k a day so I will nurse it but today when trying to get down the river it rained too muddy river mud like glue 20kph in 4x4 sideways it ran perfectly? and on the highway no surging at all? so I think I will start with a compression test
and while the plugs are out crank it and see if any coolant spits out ...............
_____ooooo
/__l_l_,\____\,___
l_---l_l__l---[ ]llllll[ ]
_.(o)_)__(o)_)--o-)_)
__________________
96 XJ Limited LPG Conversion......
99 XJ Sport ... Finally on the Road
RC Mini Me
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is On
|
|
|
All times are GMT +10. The time now is 08:36 PM.
|
|
|
|
Advertisements
|
|
|