4.0l XJ Overheating - Page 9 - AUSJEEPOFFROAD.COM Jeep News Australia and New Zealand

Go Back   AUSJEEPOFFROAD.COM Jeep News Australia and New Zealand > GENERAL > Expert Tips
Register Forums Trading Your Jeep New Garage Mark All Read

Post New Thread  Reply
 
Thread Tools Search this Thread
  #57  
Old 14-05-2011
Nakkas's Avatar
Nakkas  Nakkas is offline
Symphony Composer
 
Join Date: Jul 2009
Location: Rockingham, WA
Posts: 638
What Jeep do I drive?: XJ
Likes: 0
Liked 0 Times in 0 Posts
Default

This is the latest configuration on the V8 Jeep with the Alloy radiator.



The other setup didn't fit the alloy radiator..
__________________


XJ V8 Build
Electric water pump
  #58  
Old 22-05-2011
jake  jake is offline
CrawlerStar
 
Join Date: May 2003
Location: sa
Posts: 392
Likes: 0
Liked 1 Time in 1 Post
Default

Ive been running my alluminium radiator for awhile now. Did a few trips through summer on beaches and towed a heavy boat on hot days. Only saw approx 100 degrees once when driving on soft sand for 7 km with a 20 knot tail wind.

Temps normally stay around 92. So far temp problems are a thing of the past

touch wood!
__________________
Jake

1996 xj sport
  #59  
Old 25-11-2011
Nakkas's Avatar
Nakkas  Nakkas is offline
Symphony Composer
 
Join Date: Jul 2009
Location: Rockingham, WA
Posts: 638
What Jeep do I drive?: XJ
Likes: 0
Liked 0 Times in 0 Posts
Default

The temps here now are in the 40's and the V8 Jeep still does not have any overheating problems. I can't remember the last time the fans came on. The temps sit between 79 and 85. Not sure if it is the change to the LS1 or the alloy radiator but temp problems are a thing of the past.. Get an alloy radiator. Bonus is the trans cooler is on the correct side as well..
__________________


XJ V8 Build
Electric water pump
  #60  
Old 14-01-2012
brett6322's Avatar
brett6322  brett6322 is offline
Jeep Junkie
 
Join Date: Feb 2008
Location: Morayfield
Posts: 8
What Jeep do I drive?: XJ
Likes: 0
Liked 0 Times in 0 Posts
Default

Just fitted these two vents before relocating to cairns. Very good value, dropped about 5 degrees and has never gone above about 103 since instalation. Even fully loaded up, including roof racks on drive to cairns in 35 plus degrees. Beenliegh to Port Douglas in 24 Hours! To top it of averaged 13.1 L/100 pushed hard. Can't wait to test the vents out on some low range work!
Attached Thumbnails
Click image for larger version

Name:	Image0005.jpg
Views:	31
Size:	28.0 KB
ID:	67434   Click image for larger version

Name:	Image0007.jpg
Views:	33
Size:	24.8 KB
ID:	67435  
__________________
Gotta love a little red Jeep!!!
  #61  
Old 23-01-2012
darksidecustoms's Avatar
darksidecustoms  darksidecustoms is offline
MudSplasher
 
Join Date: Oct 2009
Location: Peakhurst, NSW
Age: 41
Posts: 1,899
What Jeep do I drive?: XJ
Likes: 419
Liked 275 Times in 139 Posts
Default

Hey Rodge did you manage to get around to the next installments on this topic? Cant seem to find them (not with Tapatalk topic search at least).
__________________
98 XJ Sport 4.0L / Intake & Exhaust / Taurus Fan / 3" OME Lift / 31x10.5 Silverstone / HID & LEDs
  #62  
Old 23-01-2012
Rodgebone's Avatar
Rodgebone  Rodgebone is offline
AJOR Gold
 
Join Date: May 2006
Location: Ocean Reef, Western Australia
Age: 60
Posts: 3,843
What Jeep do I drive?: XJ
Likes: 2
Liked 31 Times in 21 Posts
Default

no, havent got that far yet,,,,too much crap going on
__________________
there's Only One
  #63  
Old 25-02-2012
junglejuice's Avatar
junglejuice  junglejuice is offline
MonsterMoose
 
Join Date: Nov 2003
Location: Brisbane, Southside
Age: 51
Posts: 10,539
What Jeep do I drive?: WK2
Likes: 369
Liked 1,110 Times in 691 Posts
Default

After many years (8 approx of my ownership) of running what I can only assume is the original radiator fitted to my car which makes it 16yrs old the old copper/plastic unit had to be changed as it was weeping around where the tanks seal against the core.
So I flushed it all, put in an aftermarket copper/brass unit, fitted a new 192*f thermostat replacing a genuine 195*f (god only knows how old that is as the engine was swapped last year) running a new waterpump and twin electrics it now runs way cooler then it ever did.
When stock or even with the new pump and twin electrics it would sit rock solid on around 95* all day every day, on the highway, in traffic, towing my camper trailer didn't matter, heavy 4wding was the only thing that would make any difference but now the temp is all over the place from just over 1/4 (around 70*) up to the normal 90's range according to the guage, it doesn't look like a lot on the guage but when it never used to move at all it is a little odd.
What I haven't tried yet is my camper on it since the xmas overheating debacle which inspired all these replacements....
__________________
JJ

Do it once, Do it right!

2014 WK2 Overland
Post New Thread  Reply


Thread Tools Search this Thread
Search this Thread:

Advanced Search

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is On





All times are GMT +10. The time now is 03:38 PM.


Advertisements




AJOR does not vouch for or warrant the accuracy, completeness or usefulness of any message, and are not responsible for the contents of any message. The messages express the views of the author of the message, not necessarily the views of AJOR or any entity associated with AJOR, nor should any advice be substituted as technical advice replacing that of a mechanic. You agree, through your use of this service, that you will not use AJOR to post any material which is knowingly false and/or defamatory, inaccurate, abusive, vulgar, hateful, harassing, obscene, profane, sexually oriented, threatening, invasive of a person's privacy, religious, political or otherwise violative of any law. You agree not to post any copyrighted material unless the copyright is owned by you or by AJOR. The owner, administrators and moderators of AJOR reserve the right to delete any message or members for any or no reason whatsoever. You remain solely responsible for the content of your messages, and you agree to indemnify and hold harmless AJOR, the administrators, moderators, and their agents with respect to any claim based upon transmission of your message(s). The use of profile signatures to intentionally mislead or misdirect any member on this forum is not acceptable and may result in your account being suspended. Any trip that is organised through the AJOR forum is participated at your own risk. If you or your vehicle is damaged it is your responsibility, not that of the person that posted the thread, message or topic initiating the trip, nor the organisers of AJOR or moderators of any specific forum. This forum and associated website is the property of AJOR. No user data is harvested and no information supplied in your registration will be sold for profit.


Powered by vBulletin® Version 3.8.7
Copyright ©2000 - 2024, vBulletin Solutions, Inc.

AJOR © 2002 - 2024 AUSJEEPOFFROAD.COM. All corporate trademarked names and logos are property of their respective owners. Ausjeepoffroad is in no way associated with DaimlerChrysler Corporation or Fiat Jeep.
www.ausjeep.com www.ausjeep.com.au www.midlifemate.com ausjeepforum.com www.r9kustoms.com
vB Ad Management by =RedTyger=