|
|
12-11-2017
|
|
Irok Bandit
|
|
Join Date: Apr 2012
Location: Wang NSW
Age: 56
Posts: 4,434 What Jeep do I drive?: JT
Likes: 479
Liked 1,190 Times in 789 Posts
|
|
diesel-won-t-crank
__________________
SOLD 06 Limited G/C QuadraDrive II Lovells 2"Lift +30 rims 265/70/17 Imported Saguaro Bar Stedi
|
03-08-2018
|
|
Irok Bandit
|
|
Join Date: Apr 2012
Location: Wang NSW
Age: 56
Posts: 4,434 What Jeep do I drive?: JT
Likes: 479
Liked 1,190 Times in 789 Posts
|
|
06 WH Gearbox/tfer case issue
The front T/C CV is a CV-861 same as an XR8 UTE DRIVE SHAFT
Specs
•CV-861
•Outside diameter. 100mm
•Number of splines. 25
•Width. 30mm
•Non plunging
__________________
SOLD 06 Limited G/C QuadraDrive II Lovells 2"Lift +30 rims 265/70/17 Imported Saguaro Bar Stedi
Last edited by Clarky; 12-04-2019 at 11:14 AM.
|
21-08-2018
|
|
Irok Bandit
|
|
Join Date: Apr 2012
Location: Wang NSW
Age: 56
Posts: 4,434 What Jeep do I drive?: JT
Likes: 479
Liked 1,190 Times in 789 Posts
|
|
VNT Turbo actuator
A bit of info I found today about Garrett (Hella) Turbo Actuators
Sprinter and late model OM642 engines had different turbo actuators and fitting the wrong one will result in the throttle body lightning bolt symbol coming on and limp mode (commonly associated with a swirl motor failure)
Our Grands and Commanders use the G88 version.
This can be found on the alloy body of the actuator like this (example only, could be anywhere on the actuator)
A link to a US supplier https://blaast-turbo-factory.myshopi...nt=33296760783
NOTE!
Now Garrett Don't recommend you replace just the actuator (see below) But many have without a problem.
https://garrett.honeywell.com/upgrad...tuator-repair/
__________________
SOLD 06 Limited G/C QuadraDrive II Lovells 2"Lift +30 rims 265/70/17 Imported Saguaro Bar Stedi
|
14-02-2019
|
CrawlerStar
|
|
Join Date: Sep 2013
Posts: 385 What Jeep do I drive?: XH
Likes: 116
Liked 60 Times in 52 Posts
|
|
During my last service i noticed that the rubber seal in the oil cap was worn where it seals, so i pulled it out and the other side was softer.
I simply reinstalled it the other way and i have now done 5,000 k's and it has stoped leaking.
There is a little bit of oil to be seen not 100% if it was there but if that has leaked it's still a hell of a lot better.
|
11-05-2019
|
Senior Newbie
|
|
Join Date: Jun 2017
Posts: 96 What Jeep do I drive?: WH
Likes: 37
Liked 28 Times in 18 Posts
|
|
2007 WH CRD - no DPF, Swirlpot mod and egr mod done.
Engine will crank, fire then shut off in 2 seconds, and the oil lamp comes on.
This happened after the engine went into limp mode driving home today. The engine had no power, could hardly move, max speed of 30kph and was surging.
Scan showed P0471 - exhaust pressure sensor, however this should put it into limp mode, not present the above symptoms as far as I am aware. I have removed the sensor, inspected it and replaced it.
Any advice re the nil start issue would be great. At this point, even if I install a new sensor, I can't run the engine to test if that is fixed.
There is plenty of oil in the engine.
|
12-05-2019
|
|
LokRinger
|
|
Join Date: Jul 2002
Location: Victoria
Posts: 6,878
Likes: 792
Liked 1,768 Times in 560 Posts
|
|
Plugged exhaust?
|
21-10-2019
|
I just registered
|
|
Join Date: Mar 2010
Posts: 11 What Jeep do I drive?: WH
Likes: 0
Liked 0 Times in 0 Posts
|
|
When you installed your gde tune did your engine light stay on? My jeep also doesnt have a dpf. Did you order the gde tune with the dpf delete?
|
Thread Tools |
Search this Thread |
|
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is On
|
|
|
All times are GMT +10. The time now is 04:38 PM.
|
|
|
|
Advertisements
|
|
|
AJOR does not vouch for or warrant the accuracy, completeness
or usefulness of any message, and are not responsible for the contents of any
message. The messages express the views of the author of the message, not necessarily
the views of AJOR or any entity associated with AJOR, nor should any advice
be substituted as technical advice replacing that of a mechanic. You agree,
through your use of this service, that you will not use AJOR to post any material
which is knowingly false and/or defamatory, inaccurate, abusive, vulgar, hateful,
harassing, obscene, profane, sexually oriented, threatening, invasive of a person's
privacy, religious, political or otherwise violative of any law. You agree not to post any copyrighted
material unless the copyright is owned by you or by AJOR. The owner, administrators
and moderators of AJOR reserve the right to delete any message or members for
any or no reason whatsoever. You remain solely responsible for the content of
your messages, and you agree to indemnify and hold harmless AJOR, the administrators,
moderators, and their agents with respect to any claim based upon transmission
of your message(s). The use of profile signatures to intentionally mislead or misdirect any member on this forum is not acceptable and may result in your account being suspended. Any trip that is organised through the AJOR forum is participated
at your own risk. If you or your vehicle is damaged it is your responsibility,
not that of the person that posted the thread, message or topic initiating the
trip, nor the organisers of AJOR or moderators of any specific forum. This forum
and associated website is the property of AJOR. No user data is harvested and no information supplied in your registration will be sold for profit.
|